Lighthouse Marine Inc.

O/B 4-Stroke Service and Tune On Boat
Check transom drain plug
Test run
Check compression

Check for proper operating temperature
Test run and take download and note issues
Check charging, spark and cooling
Check and replace spark plugs
Spray decarbonizer through engine
Check idle speed and adjust if needed
Check fuel system for proper operation
Clean/replace fuel filters as needed
Replace water separator fuel filter
Change engine oil and filter
Run Salt-Away through engine
Check and change gear lube and washers
Check for water in lube
Pressure and Vacuum test if water found
Check speedometer pick-up
Remove and Check prop, check for fish line, grease shaft and re-install with new pin
Check for water pump output and condition
Check steering and control cables
Check total steering system for ease of operation
Check hydraulic steering system
Grease engine and steering cable
Check TNT and reservoir and fill as needed
Check neutral safety switch and lanyard
Check reverse lock
Check shift
Spray powerhead with Corrosion Block
Check boat accessories
Check all instruments and lights
Check and replace anodes as needed
Check gauges
Check horn
Check bilge pump and float switch
Check, test and service battery, replace wing nuts with lock nuts
Spin test trailer bearings
Check brake operation and fluid
Check tire psi
Great bearing buddies
Lube, winch, coupler and tongue jack.


Outboard Tune-up Off Boat

Test run and check compression

Check for proper operating temperature

Check.ignition system, check and replace sparkplugs

Spray Decarbonizer through engine

Check carb sync, check timing and adjust if needed

Check idle speed and adjust if needed

Check fuel system for proper operation

Grease all fittings

Check and change gearlube and washers, check for water in lube

Pressure and vacuum test, if water found

Remove and check prop, check for fishline

Grease shaft and install peop with new pin

Check water pump output and condition

Check tilt operation, check shift

Spray powerhead with Corrosion Block

Check final adjustments

O/B Service and Tune On boat

Check transom drain plug

Test Run, check compression, download info*

Check charging, spark and cooling,  check/replace sparkplugs & wires if needed*

Spray decarbonizer through engine*

Check carb sync, check idle speed and adjust if needed*

Check fuel system for proper operation, clean or replace filters*

Replace hi-pressure inline fuel filters if HPDI, replace water separator fuel filter

Check and fill engine oil reservoir

Check & change gearlube & washers, check for water in lube, pressure & vacuum test if water found*

Check speedometer pick up

Remove prop, check for fish line, check prop, grease shaft, install prop with new pin*

Check water pump output and condition, check compressor oil*

Check steering & control cables, check total steering ease of operation*

Check hydraulic steering system, grease engine and steering cable

Check tilt lock*, check TNT & reservoir and fill, check Trim and Tilt

Check and replace anodes as needed, check all safety functions, check shift*

Spray power head with Corrosion Block*

Check boat accessories, instruments & lights, check horn, bilge pump & float switch

Check, test & service battery, fluids, charge if needed replace battery wing nuts with locknuts

Spin test trailer bearings, check brake operation, check brake fluid, check tire pressure PSI, check spare tire PSI

Grease bearing buddies

Lubed winch, coupler and tongue jack

* Items are for Service and Tune Off Boat




Outboard New Buyer Check Out
Check transom drain plug
Test run, check compression, check charging, spark and cooling
Check spark output, check and replace spark plugs
Check carb sync
Check neutral start switch/lock out
Check fuel system for proper operation, replace water separator fuel filter
Check throttle operation
Run Salt-Away through engine
Check and change gear lube and washers
Check for water in lube, pressure and vacuum test if water found
Remove & check prop, check for fish line, grease shaft & install prop with new pin
Check cooling system, check water pump output and condition
Check compressor oil
Check steering and control cables,check total steering system ease of operation
Check hydraulic steering system, check TNT and reservoir and fill as needed, check tilt operation, check reverse lock, check shift
Spray powerhead with Corrosion Block
Check boat accessories, check all instrument and lights
Check/replace anodes as needed
Check gauges, check horn, check bilge pump and float switch
Check, test & service battery, check fluid level & fill, charge, replace wing nuts with lock nuts
Check trailer & trailer lights, spin test trailer bearings, check brake operation  & fluid, fill if needed
Check tire PSI
Grease bearing buddies, lube winch, coupler and tongue jack


We are an Authorized and Certified Dealer for:

Certified Yamaha 5-Star Dealer

Certified Mercuryand Mercruiser Dealer since 1988

Certified Bombardier - OMC, Johnson, Evinrude Dealer since 1988

Certified Volvo Service

Lighthouse Marine Inc.

Pleasurable Boating and Getting You Out on the Water Is Our Goal

5926 Sehmel Dr. NW Bldg A, Gig Harbor,  WA  98332

Email:  Lighthousemarineinc@gmail.com




253-858-7280  *  253-858-8160

Hours of Operation

May through August - Monday through Friday 8:00 am to 5:30 pm

Saturdays 9 am to noon - Closed on Sundays

September through April - Monday through Friday 8:30 am to 5:00 pm

Closed Saturday and Sunday

Tel: 253-858-7280 or 253-858-8160

5926 Sehmel Dr NW Bldg A, Gig Harbor WA 98332

Check our Trailer Page for the Outboard Services Below

Outboard 10/20 Hour Check

Outboard Verado 300 Hour Service with Water Pump

Outboard ETEC 300 Hour Service with Water Pump

Outboard Water Pump
Check transom drain plug
Test run and run Salt-Away through engine
Check and change gear lube and washers
Check for water in lube, pressure and vacuum test if water found
Check speedometer pick-up
Remove and check prop, check for fish line, grease shaft and install prop with new pin
Check water pump output and condition
Check tell-tale and water pump output
Check water tube and power head restrictions
Replace water pump parts as needed
Spray power head with Corrosion Block
Check tire pressure PSI
Grease bearing buddies
Lube winch, coupler and tongue jack.

Outboard 4-Stroke Oil Change

Check transom drain plug
Check for proper operating temperature, test run & take download and note issues
Replace water separator fuel filter
Warm up Engine, change engine oil and filter, grease all fittings
Check and change gear lube and washers
Check for water in lube, pressure and vacuum test if water found
Check all safety functions
Spray power head with Corrosion Block
Check spare tire PSI
Lube winch, coupler and tongue jack