We are an Authorized and Certified Dealer for:

Certified Yamaha 5-Star Dealer

Certified Mercuryand Mercruiser Dealer since 1988

Certified Bombardier - OMC, Johnson, Evinrude Dealer since 1988

Certified Volvo Service

Lighthouse Marine Inc.

Pleasurable Boating and Getting You Out on the Water Is Our Goal

5926 Sehmel Dr. NW Bldg A, Gig Harbor,  WA  98332

Email:  Lighthousemarineinc@gmail.com




253-858-7280  *  253-858-8160

Hours of Operation

May through August - Monday through Friday 8:00 am to 5:30 pm

Saturdays 9 am to noon - Closed on Sundays

September through April - Monday through Friday 8:30 am to 5:00 pm

Closed Saturday and Sunday

Tel: 253-858-7280 or 253-858-8160

5926 Sehmel Dr NW Bldg A, Gig Harbor WA 98332

Stern Drive Basic New Buyer Check Out
Check Transom Drain Plug
Test run and check compression
Check for proper operating temperature
Check charging, spark and cooling, c
heck ignition system
Check for marine components
Run Salt-away through engine
Check choke operation
Check fuel system for proper operation, replace water separator fuel filter
Check condition of belts and tighten
Check & change gearlube & washers, check for water in lube, pressure & vacuum test if water found

Check speedometer pick up
Remove drive, inspect u-joints and bell housing
Check shift cable and engine alignment
Install drive, replace gaskets and seal
Remove and check prop, check for fish line
Grease shaft and install prop with new pin
Check cooling system, check water pump output and condition
Check steering and control cables
Check total steering system ease of operation, check hydraulic steering system, check and top off power steering fluid
Check trim wear pads
Check all safety functions

Check shift cable and engine alignment
Perform audio and visual check, check overall condition
Check boat accessories, check instruments and lights
Check anodes replace as needed
Check blower, check gauges
Check bilge pump and float switch
Check, test & service battery, check battery fluid & fill, charge battery, check connections, replace wing nuts with locknuts
Advise customer of any problems
Spin test trailer bearings, check brake operation, check brake fluid
Check spare tire PSI, check tire pressure PSIGrease bearing buddies, lube winch, coupler and tongue jack

Stern Drive 20 Hour Check
Check transom drain plug
Test run, check for proper operating temperature
Test run and download info
Check carb for leaks and operation
Check idle speed and adjust if needed
Replaced water separator fuel filter
Change engine oil and filter
Check condition of belts and tighten
Run Salt-away through engine
Check and change gearlube and washers
Check for water in lube, pressure & vacuum test
Clean gearlube monitor and fill
Check hydraulic steering system
Check and top off power steering fluid
Check TNT and reservoir and fill
Check tilt operation
Check all safety functions
Spray powerhead with Corrosion Block
Check overall condition
Check instruments and lights, check blower
Check gauges, check horn
Check bilge pump and float switch
Check final adjustments
Check brake operation, check brake fluid
Check spare tire PSI, check tire pressure PSI
Grease bearing buddies
Lube winch, coupler and tongue jack

To add a full service and tune, engine and outdrive service to a new buyer check, use above and then add the ** items

Stern Drive Tune up (**)
Check transom drain plug
Test run
Check compression
Check for proper operating temperature
Test run and take download and note issues
Check and replace spark plugs and wires
Check and replace cap and rotor
Check points and condenser
Set point dwell and engine timing
Check engine for marine components
Check carb for leaks and operation
Check carb sync
Check choke operation
Check idle speed and adjust if needed
Clean/replace fuel filters as needed
Replace water separator fuel filter
Check condition of belts and tighten
Clean flame arrestor
Run Salt-Away through engine
Check power steering fluid – top off
Check tilt operation
Check all safety functions
Spray power head with Corrosion Block
Check boat accessories
Check all instruments and lights
Check blower
Check gauges
Check horn
Check bilge pump and float switch
Check, test and service battery, check fluid, charge, replace wing nuts with lock nuts
Check trailer and trailer lights
Check brake operation and fluid
Check spare tire pressure PSI
Grease bearing buddies
Lube winch, coupler and tongue jack
.

Full Stern Drive Service and Tune, Engine and Outdrive Service (includes  ** above)

Stern Drive Engine Service (**)
Check transom drain plug
Test run
Check proper operating temperature
Clean/replace fuel filters as needed
Replace water separator fuel filter
Change engine oil and filter
Check condition of belts and tighten
Run Salt-Away through engine
Check fresh water cooling antifreeze
Change anode in heat exchanger
Check total steering system ease of operation
Check power steering fluid – top off
Check all safety functions
Spray power head with Corrosion Block
Check boat accessories
Check all instruments and lights
Check blower
Check gauges
Check horn
Check bilge pump and float switch
Check test and service battery, check fluid and fill, charge, replace wing nuts and lock nuts
Check brake operation and fluid
Check tire pressure PSI
Grease bearing buddies
Lube winch, coupler and tongue jack.

Stern Drive Outdrive Service (**)
Check transom drain plug
Test run
Run Salt-Away through engine
Check bellows and hoses
Check and change gear lube and washers, check for water, pressure & vacuum test if water found
Check speedometer pick-up
Remove drive, check u-joints and bellows, gimble bearing
Install drive, replace gaskets and seals
Remove and check prop, check for fish line, grease shaft and replace prop with new pin
Clean gear lube monitor and fill
Check the trim wear pads
Check tilt operation
Check shift cable and engine alignment
Spray powerhead with Corrosion Block
Check/ replace anodes as needed
Check tire pressure PSI
Grease bearing buddies
Lube winch, coupler and tongue jack

Stern Drive Outdrive Water Pump
Check transom drain plug
Run Salt-Away through engine
Check and change gear lube and washers, check for water, pressure & vacuum test if water found
Check speedometer pick-up
Clean gear lube monitor and fill
Check outdrive for heat damage
Check water pump output and condition
Check tell-tale and water pump output
Replace water pump parts as needed
Check the trim wear pads
Check all safety features
Check/replace anodes as needed
Check spare tire PSI
Grease bearing buddies
Lube winch, coupler and tongue jack

Lighthouse Marine Inc.